Astra to return to flight with mission for Spaceflight Inc.

Date:
Mon, 14 Mar 2022 13:33:59 +0000

Description:
Rocket 3.3, the first Astra rocket to successfully launch to orbit, will be returning to The post Astra to return to flight with mission for Spaceflight Inc. appeared first on NASASpaceFlight.com .

FULL STORY ======================================================================

Rocket 3.3, the first Astra rocket to successfully launch to orbit, will be returning to flight in what is sure to be a closely watched mission just over one month after ELaNa-41 failed during fairing and stage separation. The launch is scheduled for Monday, March 14, in a 29-minute launch window that opens at 9:22 AM PDT (16:22 UTC). A backup launch window exists on Tuesday, March 15.

This mission for Spaceflight Inc., designated Astra-1, will use the LV0009 vehicle to lift off from Launch Pad-3B at the Pacific Spaceport Complex in Kodiak, Alaska, which was where all of Astras test flights, including the successful orbital launch of LV0007, had occurred. Kodiak is the first of two active Astra launch sites, alongside Cape Canaveral which hosted the flight
of LV0008 in February.



LV0009 will launch along a southerly trajectory toward a Sun Synchronous
orbit inclined 97.5 degrees to the equator at an altitude of 525 kilometers. Three minutes after liftoff, the first stages five kerosene and liquid oxygen-fueled Delphin engines, fed by electric pumps and with a thrust of
6500 lbs each, will cut off, and the all-important fairing separation will commence.



The fairing separation is necessary not just for satellite deployments, but also for the second stage to separate since it is also covered by the
fairing. Using the fairing to protect both the payloads and the upper stage during atmospheric flight makes the stage lighter and simpler than it otherwise would be. See Also LV0009 Updates Commercial Space Forum Section L2 Future Vehicles Section Click here to Join L2

On the ELaNa-41 LV0008 launch, the flight went as planned until this critical step. An error in a wiring diagram caused two wiring harness channels to be swapped in an incorrect order. Due to this error, the separation devices
fired incorrectly causing an electrical disconnect.

This disconnect prevented the last separation device from receiving its command to fire, so the fairing was not able to separate correctly. After the second stage ignited and finally separated from the first stage, a second issue, one with the flight control software on the upper stage, doomed the ELaNa-41 mission.

Missed signals started a chain of events that resulted in a packet loss, the loss of packets of data that prevented the flight control software from controlling the stages motions with its thrust vector control (TVC) system that controls the stages engine nozzle.

Astra was able to replicate both of these failures during the resulting investigation. The fairing separation failure was replicated with hardware on the factory floor being built for upcoming flights, while the software
failure was replicated with a hardware-in-the-loop simulator. LV0009 conducts a static fire test in Kodiak, Alaska ahead of launch. (Credit: Brady
Kenniston / Astra)

The flight hardware on the Astra-1 mission and subsequent flights has been fixed to prevent the fairing failure mode seen on ELaNa-41, while the
software has been given three modifications to reduce the possibility of packet loss. Astra is confident that the issues LV0008 encountered will not recur.

Once LV0009s fairing separation sequence is complete, the second stage will separate and ignite its single pressure-fed Aether engine with 740 lbs of thrust. This engine, also using kerosene and liquid oxygen, is equipped with
a large vacuum-optimized nozzle, and will fire from T+3:15 to T+8:40. 10 seconds after second engine cutoff, the payload deployment sequence will start.

Payloads for three different customers, all managed by Spaceflight Inc., will be carried on this flight. These include NearSpace Launchs experimental S4 Crossover payload platform and the Portland State Aerospace Societys OreSat0, the first satellite built by the state of Oregon. OreSat0 was originally scheduled to launch on the SpaceX Transporter-3 mission.

S4 Crossover is a prototype host platform that includes a Globalstar transmitter and an Iridium transceiver, along with environmental instruments to measure radiation and plasma densities that future payloads the platform might carry can be exposed to. The host platform will be powered by fixed solar panels mounted to the structure. LV0009 is transported through Alameda, Californian toward the launch site in Alaska. (Credit: Astra)

Similar to the STP-27AD2 payload on the successful LV0007 flight last
November , the S4 Crossover platform will not be separated from the second stage. S4 Crossover is expected to operate in space for a few weeks before it reenters the atmosphere along with the second stage.

If all goes well, the OreSat0 will become one of the first satellites ever deployed by an Astra launch vehicle. OreSat0 is a 1U CubeSat that will be a pathfinder for an upcoming 2U CubeSat to launch on a future NASA CubeSat Launch Initiative (CSLI) flight. The future OreSat 2U spacecrafts objectives are climate science (measuring high altitude cirrus clouds) and STEM
outreach.

The third customer on board Spaceflights Astra-1 mission has not been disclosed. LV0009 is the first of a multi-launch contract between Astra and Spaceflight Inc.

The LV0009 flight comes before a key earnings report for the publicly traded Astra company on March 17, and this return to flight mission will be watched with great interest by customers, industry observers, and investors. Astra
has plans for upcoming Rocket 4 and 5 versions along with weekly and ultimately daily launch cadences.

If LV0009 succeeds, it would be the second successful orbital flight attempt for Astra. Next up on the companys manifest is three flights from Cape Canaveral in support of NASAs TROPICS mission.

(Lead photo: LV0009 stands vertical at Kodiak before launch. Credit: Brady Kenniston/ Astra)

The post Astra to return to flight with mission for Spaceflight Inc. appeared first on NASASpaceFlight.com .



======================================================================
Link to news story: https://www.nasaspaceflight.com/2022/03/astra-return-to-flight/


--- Mystic BBS v1.12 A47 (Linux/64)
* Origin: tqwNet Science News (1337:1/100)